Go
The Monolithic Dome
 
Site Index
 
Homes
Schools
Sports
Churches
Commercial
Nonprofit
Storages
 
Foam
Airforms & Coatings
Equipment
 
Disaster Resistant
 
Planning & Design
Construction & Training
 
President's Sphere
 
Dome News
 
Bulletin Board
Builder Listings
Insurance
Lenders
 
Workshops
Conference
 
Marketplace

Fresh Air and ERVs

July 23, 2003

by David B. South

The Issue

How do you bring fresh, breathable air inside the home without losing the dome's energy efficiency?

Carbon dioxide gas (CO2) has many sources. We produce CO2 when we breathe and plants give off CO2 when the sun is not shining. (They give off oxygen when the sun is shining.) Combustion also produces CO2, as do coal-fired energy plants, cars, trucks, etc.

High levels of CO2 in a home can be indicative of poor overall air quality. For instance, one can assume that if CO2 levels are high, so are other pollutant levels such as outgassing from carpets or furniture and pet dander.

Since June of 2002 , the Monolithic Dome Institute (MDI) has been monitoring CO2 in many homes -- both domes and conventional. They all have too much CO2 most of the time. If windows are opened, CO2 levels drop to 450 parts per million (ppm)-- the same as outside. But modern houses are airtight, and Monolithic Domes are the tightest of them all. Consequently, CO2 levels can rise drastically over short periods of time.

For commercial buildings, 1200 ppm is considered the trigger point for fresh air intake. So we are assuming that 1200 ppm is the maximum we should have in our houses.

It was a surprise to us to discover (in both conventional and Monolithic Dome homes) how often we found the CO2 levels above 1200 ppm. OSHA has 5000 ppm as a maximum for workers' health for eight hours. We were shocked to find that, at times, the CO2 in some homes reached 4000 ppm.

The Answer

We believe we have found the answer to the CO2 issue. It comes in the form of an ERV (Energy Recovery Ventilator-- often called an HRV, Heat Recovery Ventilator). These machines bring outside "fresh" air into the home and exhaust an equal amount of the home's stale air.

And, as if by magic, ERVs also recapture most of the heat from the respective air streams. This is done in the box by an air-to-air heat exchanger. By recovering the heat, we spend less to heat or cool the exchanged air, thus saving huge amounts of energy.

In Canada, all new homes must install an ERV. Studies have led us to conclude that we should follow suit. After extensive research, MDI has found an ERV unit that works very well.

Permanent Solution

We next installed a slightly larger RenewAire EV130 ERV in my home. It is a permanent model, but we installed it in a window for closer monitoring.

As many of you know, my house consists of two, 40-foot-diameter Monolithic Domes with a central connector. Each of the domes has a 1.5 ton AC unit with internal ducting. Surprisingly, we found serious air mixing from each dome. The single unit in the living room does well for the entire house.

After we have completed our experiments, we will install this ERV permanently in the furnace space. Our experiments have shown it will work perfectly there. This ERV sells for about $700. (Buy Now.)

My home is now always under the 1200 ppm level-- even with lots of company. We can also shut off the ERV for a few hours each day if we wish.

We have recently installed an ERV in a church facility Monolithic Dome that is working very well. It has cut the air conditioning need in half.

In my opinion, every home and most commercial buildings should have an ERV.

Chew On This:

Keep in mind that there are many days when we could heat or cool the dome using just fresh air. Example: This morning it was 57 degrees outside and my air conditioner was running. It was cooling the shell a bit from yesterday's temps in the upper 80s. If we had a good way to bring in lots of air at those times, we could use it to charge the dome's thermal battery. On the other hand, we do not want outside air during an ozone alert, or when it's very humid-- even if the temperature is optimum.

At present, I'm searching for a furnace that pulls fresh air from the outside, on command, either full-flow or through an ERV. It will be controlled by a simple computer/thermostat system that can be programmed for a full range of possibilities. Properly equipped and programmed, this system could keep the air fresh while heating and cooling the Monolithic Dome as needed, using virtually no energy, for much of the year.

Related Articles:
 


177 Dome Park Place - Italy, TX 76651
Tel (972)483-7423 - Fax (972)483-6662
| Press Room